Solar Converters Inc -PPT 12/24-40 Linear Current Booster/Pump Driver 40A

Solar Converters Inc -PPT 12/24-40 Linear Current Booster/Pump Driver 40A

Model: PPT 180-10

Brand: Dankoff Solar

Price: $795.00 


 

Solar Converters Inc -PPT 12/24-40 Linear Current Booster/Pump Driver 40A

These LCB's are used for the Dankoff Solaram 24VDC surface pumps. For array sizes of 1200w at 24v and above two 12/24-40 units can be used in conjunction with a Heat Sink and Diode Kit.

Application

Used to control and power a DC motor from a solar panel. The unit prevents stalling of the motor under less than full sun condition. The power of the sun is transformed to the motor running conditions so as the sun goes down the motor slows down instead of stalling. Conversely, or as the sun comes up the motor starts running much earlier instead of staying stalled for hours when it could be running. This translates into more running time of the motor where it spends a lot of time working instead of stalled doing no work.

 

Model: PPT 48-10

Features

 

  • Voltage Limited Output
  • Internal Fuse- 10 amp automotive style fuse
  • Greatly increases water flow, even under reduced sunlight conditions (over 40% likely)
  • Transient Protected on the input and output
  • Float Switch Input for on/off control
  • Ultra High Efficiency >94 %
  • Weatherproof NEMA enclosure

 

 



 

** Special units have a suffix of M XX after the part number. The maximum output voltage of the pump driver is XX. For example PPT 12/24 - 15 M6 will power a 6 V motor from a nominal 12 V solar panel. Note that the motor current increase by the ratio of approx. 15/6. Thus a 1 amp 12V nominal solar panel will power the motor at 2.5 Amps.

 

Mechanical Specifications

Weight:

  • approx. 2 lb.

Size:

  • 4.5" X 2.5" X 2" nominal, resembling a junction box with mounting feet

Operating Temperature:

  • -40 to 70 deg. C

Humidity:

  • N/A NEMA 4 enclosure

Connections

    • Power: PV and Load
 
 
  • 6 inch # 16 AWG flying leads
 
  • Input: Red = PV +, Black = PV -
 
  • Output: White = Pump +, Blue = Pump -
 
    • Signal: float switch,
 
 
  • 6 inch # 24 flying leads yellow: connect to PV - = OFF for float switch operation
 
  • 6 inch # 24 flying leads purple: connect to PV - = 24 V operation disconnected = 12 V operation
 
  • 6 inch # 24 flying leads red / black: Output Current Sense scaled at 50 mv = 10 A
 

Application Notes

  1. This Pump Power Tracker(TM) is quite capable of putting out over 15 amps into a stalled load even from a single 30 watt 4.5 amp panel. It is recommended that a fuse or overtemperature switch matched to your pump motor be incorporated in the system to protect your pump or motor.
  2. Float switch operation draws microamps of current, i.e. small wire gauge, allowing long distance runs between float switches / holding tanks, and PV / pump driver without the need to string long lines of heavy gauge wire.
  3. Unit is a true 15 amp unit, all necessary derating already accounted for. Unit is capable of 20 amp operation with normal derating practices.
  4. As with all electronics, it is recommended the unit not be mounted in direct sunshine.
  5. Solar panel or energy limited input only.

 

Note: In the interest of continuous product improvement, specifications subject to change without notice.


There are currently no product reviews.


  Write Review

  Related Products


  Related Categories


  Related Manufacturers


Dankoff Solar

Dankoff Pump Spin Down Sediment FilterDankoff Pump, Flowlight Booster, 2920-24 24VDC StandardDankoff Pump, Flowlight Booster, 2920-48 48VDC StandardDankoff Pump, Flowlight Booster, 2920-115 115VAC StandardDankoff Pump, Flowlight Booster, 2920-12 12VDC StandardDankoff Pump, Flowlight Booster, 2930-48 48VDC 1/2HP StandardDankoff Pump, Flowlight Booster, 2910-12 12VDC Low FlowDankoff Pump, Flowlight Booster, 2910-24 24VDC Low FlowDankoff Pump, Flowlight Booster, 2910-48, 48VDC Low FlowDankoff Pump, E-Z Installation Kit for Flowlight Booster Pumps, EZ2900Dankoff Pump, Dry Run Switch for Booster and Slow Pumps 2500/2600s, EZ2900Dankoff Pump INLINE SEDIMENT FILTER HOUSING, 10IN, CLEAR, DANKOFF 11033Dankoff Pump FILTER CARTRIDGE 10 MICRON ( 2 pack)Dankoff Pump 30" Filter and Foot Valve AssemblyDankoff Solar Force Piston Pump 3020-24BDankoff Solar Force Piston Pump Body and Water Box Only 3516Dankoff Solar Slow Pump Model 2507-XXDankoff Solar Slow Pump Model 1303-XXDankoff Solar Slow Pump Model 1308-XXDankoff Solar Slow Pump Model 1322-XXDankoff Solar Slow Pump Model 2607-24XX, 24VDCDankoff Solar Slow Pump Model 2607-48XX, 48VDCDankoff Solar Slow Pump Model 2607-115, 115 VACReplacement Slowpump Head including Reducers for 2507/2607Dankoff Solar Slow Pump Model 2607-115, 115 VACDankoff Solar Slow Pump Model 1408-XXDankoff Solar Slow Pump Model 1403-XXDankoff Solar Suncentric Pump 7324 Min 117w array8543-120 Solaram Surface Pump up to 960' Head, 120VDCHeat Sink & Diode Kit For combining like PPT Controllers in ParallelDankoff Solar Force Piston Pump 3040-xxPV PV direct pumpDankoff Solar Force Piston Controller PPT16D 24vDankoff Solar Force Piston Controller PPT4810 48vDankoff Solar Float Switch Kit Off at EmptyDankoff Solar Float Switch Kit Off at FullDankoff Solar Force Piston Pump 3040-24BDankoff Pump, E-Z Installation Kit for Solar Force Piston Pumps, EZ3000Dankoff Solar Force Piston Pump Solar/Battery Powered Kit 9gpm, 200-400 gpdDankoff Solar Suncentric Pump 7212 12v Battery/PV PumpDankoff Solar Suncentric Pump 7322 24v Battery/PV PumpDankoff Solar Suncentric Pump 7622 48v Battery/ 36v PV PumpDankoff Solar Suncentric Pump Spin Down FilterDankoff Solar Suncentric Pump 7526 24v PV Direct PumpDankoff Pump Controller PPT16D 12/24/36vReplacement Slowpump Head including Reducers for 1303/1403/1310Dankoff Solar Slow Pump Model 1304-XXDankoff Pump, Flowlight Booster, Replacement motor for 2920-12, 24, 48Dankoff Pump, Flowlight Booster, Replacement Pump Head for Flowlight booster pump 2920-12, 24, 48Dankoff Solar Suncentric Pump 7511 24v Battery PumpDankoff Solar Force Piston Pump 3020-12BDankoff Solar Force Piston Pump Packing Kit Only #2588Dankoff Solar Force Piston Pump 3020-xxPV PV direct pumpDankoff Pump, Dry Run Switch for Slow Pumps 1300/1400Dankoff Pump Empty Tank Shut Off Float SwitchDankoff Pump Full Tank Shut Off Float SwitchDankoff Solar Force Piston Pump SolarForce Seal & Belt Kit for 3020-12, 24 or 48 PVDankoff Solar Force Piston Pump SolarForce Brush Kit for 3020-48 PVDankoff Solar Force Piston Pump Conversion Motor to change 3040-24B to 3040-48BDankoff Solar Force Piston Pump Expansion Tank Part #3600Dankoff Solar Force Piston Pump Rivetted PV Pulley #3507Dankoff Solar Force Piston Pump Bushing # 3512Dankoff Solar Force Piston Pump 3040-115 AC pumpDankoff Solar Suncentric Pump 7443 48v Battery/ 36v PV PumpDankoff Solar Force Piston Pump Replacement Motor for 3020-1158222-24 Solaram Surface Pump up to 960' Head, 24VDCSolar Converters Inc -PPT 12/24-40 Linear Current Booster/Pump Driver 40ADankoff Pump Controller PPT30D 12/24vDankoff Solar Force Piston Pump Replacement Motor for 3020/3040-24bDankoff Solar Force Piston Pump Cup Leathers for 3040Dankoff Solar Slow Pump Replacement motor for 2505 115vDankoff Solar Slow Pump Replacement Shaft Coupler Kit 2531Dankoff Solar Force Piston Pump Basic Repair kit for 3040Dankoff Solar Suncentric Pump 7446 48v PV Direct Pump/ 36v BatteryDankoff Solar Force Piston Pump 3020-48BDankoff Solar Force Piston Pump 3040-48BDankoff Pump 30" Filter Pack of 3Dankoff Solar Slow Pump Replacement Brushes for 1322-115VACDankoff Pump, Flowlight Booster, Replacement motor for 2910-12, 24, 48Sunrotor SR6 install Kit KIT-SR-6/M100TDankoff Solar Slow Pump Replacement Brushes for Flowlight 1300/2500 series pumpsDankoff Solar Brushes for Brushes for 2930-48 (Pre-2012 2920-48)Dankoff Solar Suncentric Pump 7323 12v Battery/PV PumpDankoff 1517 Replacement motor for Suncentric Surface Pump 7321-7325
Twitter
Stumbleupon
Reddit
Pintrest
Newsvine
Linkedin
Google+
Google
Facebook
Digg

QUOTE

  ME

Quote Request